check engine AUDI A8 1998 D2 / 1.G 01V Transmission Gear Oil Differential Workshop Manual

39-40


Gear oil in center differential

Gear oil in center differential, checking
and topping off


Repair Manual, Engine Mechanical, Repair Group 26; removing and
installing exhaust system
Repair Manual, Engine Mechanical, Repair Group 26; removing and
installing exhaust system
Tightening torque - If necessary, loosen or remove relevant parts of the exhaust system to
gain access to oil filler plug (arrow B): - Remove oil filler plug (arrow).

Specification: Oil level should reach lower edge of oil filler hole.
- If necessary, top up gear oil. Specification page 00
-24
.
- Always replace oil filler plug.
- Install new oil filler plug.
- Secure or re-install exhaust system free of stress:Component
Nm
Oil filler plug 35
Pa
ge 1 of 5 Gear oil in center differential
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.AT01.39.3

39-42

Filling up gear oil

Repair Manual, Engine Mechanical, Repair Group 26; removing and
installing exhaust system
Note:
There is a distinction made between two cases:
-A Center differential was not removed
-B Center differential was removed
A - Center differential was not removed (e.g. after removing and
installing drive flange) - If necessary, loosen or remove relevant parts of the exhaust system to
gain access to oil filler plug (arrow B):

Note:
If it was necessary to loosen or remove the exhaust system, this must be
re-secured or re-installed for the road test. It must be removed and
installed again for the final oil level check. - Remove oil filler plug (arrow B).
- Top up transmission fluid to lower edge of oil filler hole. Specification
and capacity page 00
-24
.
- Install old oil filler plug.
Pa
ge 3 of 5 Gear oil in center differential
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.AT01.39.3